石墨含量对石墨/铜复合材料载流摩擦磨损性能的影响
- 文件大小:561.17KB
- 浏览次数:
- 发布时间:2017-03-02
本资料包含pdf文件1个,下载需要1积分
Efects of Graphite Content on Current Carrying Friction and WearBehaviors of Graphite/Copper CompositesLv Lehua Sun Lemin Shangguan Bao Zhang Yongzhen(Institute of Materials Science and Enneefing,Henan University of Science and Technology,Luoyang Henan 471003,China)Abstract:The effects of graphite content on current carrying friction and wear behaviors of graphite/copper compositeswere investigated on a self--made pin-disk tester under diferent curent density with graphite/copper composites andQCr0.5 as friction pairs.The results show that with the increase of graphite content,the friction coefficient of the compos-ites is reduced,and the curent-carrying efficiency and the wear rate are reduced first and then increased.The compositeshave the best curent-carrying efficiency when the graphite weight content is 10% ,and the lowest weal"rate when thegraphite weight content is 12.5% .With the increasing of current density.the friction coefficient and curent-carrying efi-ciency are reduced,and the wear rate are increased.There are adhesive wen/",abrasive wear and arc ablation in the experi-ment,and arc ablation is serious when the curent density is large。
Keywords:composite materials;graphite;friction coefficient;wear rate;curent-carrying efficiency高速运动的机车是通过受电弓从悬挂的接触网上得到电能从而不断获取动力-- ,为电力机车的安全可靠运行提供足够的牵引动力。滑板质量稳定是高速列车正常行驶的前提,在高的速度、电压和电流条件下,受电弓滑板运行中由于离线等因素与接触网导线不断产生机械冲击,同时它与接触网导线又构成了-对机械与电气耦合的特殊摩擦。因此人们对受电弓滑板性能的要求也越来越高,滑板不仅需要有良好的导基金项目:国家自然科学基金项目 (50975078);国家重点联合基金项目 (U1034002);973计划前期研究专项 (2010CB635113);河南势技厅省院科技合作项目 (112106000034)。
收稿日期:2012-07-04作者简介:吕乐华 (1987-),男,硕士研究生,从事材料干摩擦学研究.E-mail:lvlh1987###163.com。
通讯作者:孙乐民 (1965-),男,博士,教授,目前主要从事材料摩擦学方面研究.E-mail:sunlm###mail.haust.edu.cn。
石墨/铜复合材料不仅具有良好的强度、硬度、导电导热性、耐蚀性,而
- 1汽车变速箱的典型工装及翻转装置设计
- 2铃木摩托车三维模型SolidWorks设计
- 3流化床干燥器设计
- 4GB/T 23901.2-2019 无损检测 射线照相检测图像质量 第2部分:阶梯孔型像质计像质值的测定
- 5广联达培训楼施工图
- 6济南某大型体育场钢结构管桁架现场拼装、组装施工方案(创鲁班奖)_secret
- 7DL/T 1151.9-2012 火力发电厂垢和腐蚀产物分析方法 第9部分:氧化钙和氧化镁的测定
- 8俏江南集团【上海兰会所施工图】
- 92009年监理工程师质量、投资、进度控制真题(含答案)
- 10立轴的工艺系统设计
- 11全套公厕建筑设计
- 12玉祥村沼气池给排水工程施工图纸
- 13高瓦斯高硫残煤地下气化清洁能源技术
- 14GB/T 12353-1999 拱形金属爆破片装置分类与安装尺寸
- 15工程质量实测记录表(砌体)